一、天然氣脫硫設備的工作原理：
1、 Working principle of natural gas desulfurization equipment:
原料天然氣進入脫硫設備界區,先是經過一個原料氣分離器,通過重力作用將原料氣中攜帶的少量游離水清理掉,然后氣體從脫硫塔頂部通過塔內脫硫劑床層,氣體中的H2S被脫除。凈化天然氣從塔底出來,進入凈化氣過濾分離器,分離出氣體中可能夾帶的脫硫劑粉塵,出凈化氣過濾分離器的天然氣直接匯入輸氣總管。至于再生操作,由于操作條件很難控制,且再利用成果不佳，故目前脫硫劑均一次性使用。
When the feed gas enters the battery limit of desulfurization equipment, it first passes through a feed gas separator to remove a small amount of free water carried in the feed gas by gravity, and then the gas passes through the desulfurizer bed in the tower from the top of the desulfurization tower, and the H2S in the gas is removed. The purified natural gas comes out from the tower bottom and enters the purified gas filter separator to separate the desulfurizer dust that may be entrained in the gas, and the natural gas from the purified gas filter separator directly flows into the gas transmission main pipe. As for the regeneration operation, since the operating conditions are difficult to control and the reuse results are poor, the desulfurizer is currently used once.
根據氣質條件、處理量和場站規劃建設方案等具體情況，可選擇不同的干法脫硫工藝方案。當前方案有原料氣分離器＋雙塔＋凈化氣過濾分離器。除此外還有雙塔＋凈化氣過濾分離器、原料氣分離器＋四塔＋凈化氣過濾分離器、四塔+凈化氣過濾分離器方案等等。
Different dry desulfurization process schemes can be selected according to the specific conditions such as gas quality conditions, treatment capacity and station planning and construction scheme. The current scheme includes feed gas separator + double tower + purified gas filter separator. In addition, there are schemes of double tower + purified gas filter separator, feed gas separator + four towers + purified gas filter separator, four towers + purified gas filter separator, etc.
二、天然氣脫硫設備技術特點：
2、 Technical features of natural gas desulfurization equipment:
（1）脫硫劑，具有硫容高、強度大等優點，其實際硫容可達25%～30%（質量分?jǐn)?shù)）;
(1) Desulfurizer has the advantages of high sulfur capacity and high strength, and its actual sulfur capacity can reach 25% ~ 30% (mass fraction);
（2）脫硫劑可在0.1～8.0MPa壓力范圍內操作，且只脫除H，S不脫除CO2，凈化氣H，S含量可達一類天然氣的要求;
(2) The desulfurizer can be operated within the pressure range of 0.1 ~ 8.0MPa, and only h and s are removed without CO2. The content of H and s in purified gas can meet the requirements of class I natural gas;
（3）設備的流程和設備都簡單，操作方便，可實現無人值守;
(3) The process and equipment of the equipment are simple, easy to operate and unattended;
（4）設備投資和生產成本均較低，除裝料時需少量耗能外，在運行條件下基本無能耗;
(4) The equipment investment and production cost are low. Except for a small amount of energy consumption during loading, there is basically no energy consumption under operating conditions;
（5）有廢渣處理問題，但廢渣對人、畜沒損害，對環境不構成污染，對堿性土壤有一些改良作用;
(5) There is the problem of waste residue treatment, but the waste residue does not damage people and livestock, does not pollute the environment, and has some improvement effect on alkaline soil;
（6）使用固體脫硫劑的天然氣脫硫設備，潛硫量越佳范圍為H2S脫除量≤150kg/d，（按原料氣含硫量不同），節約了操作成本。
(6) For the natural gas desulfurization equipment using solid desulfurizer, the better the sulfur potential is, the H2S removal amount is ≤ 150kg / D (according to the sulfur content of feed gas), which saves the operation cost.
魯公網安備37011202000764號號 網站地圖XMLTXT
企業二維碼
2021-09-08
